| Click to Post a New Message!
Page [ 1 ] |
|
|
|
John Deere Gator 6 x 4 wont run
I have a 2005 6 x 4 air cooled, just got it at auction. never was able to start except starter fluid sprayed in carb. Rebuilt the carb.(lots of gelling going on) and still the same. Replaced plugs, fuel filter (twice), drained and cleaned fuel tank. seems to fill fuel filter quickly while cranking but still will not fire unless starter fluid is sprayed in carb. Any help would be great! Has electric solinoid on bottom of bowl?? If inop. is that my problem?? Thanks for the Help. Bob
|
|
 Add Photo
Bookmarks: |
|
| |
|
John Deere Gator 6 x 4 wont run
After starting it with fluid does it continue to run?
|
|
Add Photo
Bookmarks: |
|
| |
|
John Deere Gator 6 x 4 wont run
no, it wont run on its own
|
|
Add Photo
Bookmarks: |
|
| |
|
John Deere Gator 6 x 4 wont run
If there's fuel to the carburetor then my guess is then either the carb is still messed up or the engine has very low compression.
|
|
Add Photo
Bookmarks: |
|
| |
|
John Deere Gator 6 x 4 wont run
Thanks, will check compression in the a.m. and let you know.
|
|
Add Photo
Bookmarks: |
|
| |
|
John Deere Gator 6 x 4 wont run
After rereading your original post I missed the electric solenoid part. Not sure what that does, so can't rule it out. Maybe it closes to prevent fuel from draining into the crankcase when the engine is off? When you cleaned the tank did you refill it with very fresh fuel or fuel that's been stored for six months or more? Some of my engines (esp. Hondas) won't start or run on fuel that is more than ~two months old unless it was treated with Stabil.
|
|
Add Photo
Bookmarks: |
|
| |
|
John Deere Gator 6 x 4 wont run
I've never worked on an air cooled 6x4 but I know HPXs have a shut off solenoid on the carb to prevent run on after the ignition is shut off. The solenoid pulls a plunger back when the ignition is turned on allowing fuel to flow into the carb. To check yours, unplug it ( hopefully it is plugged in to start with, because it won't run if it isn't plugged in ) and stick a test light in the plug and turn the ignition on, the light should light. If it does, your solenoid is bad, if it doesn't, you have to check that wire and find out why it isn't hot when the ignition is turned on. If the wire isn't hot, try a jumper wire from a 12V source to the connection on the solenoid and see if your gator will start that way. I think solenoids are about 150.00 for an HPX. Cheap way to fix is cut the end off so it can't go into the fuel passage when shut off. I'm not recommending that, but it would get you going until you could get a solenoid.
|
|
Add Photo
Bookmarks: |
|
| |
|
John Deere Gator 6 x 4 wont run
The fuel was fresh, unlike the stuff that was cleaned out. will keep working on it and keep you posted. Thanks
|
|
Add Photo
Bookmarks: |
|
| |
|
Page [ 1 ] | Thread 160695 Filter by Poster:
1 | 3 | 4 |
|
()
Picture of the Day
DennisCTB
Unanswered Questions
Active Subjects
Hot Topics
Featured Suppliers
|
Gas Generator Weather Protecti
02-28-2009, 20:57 
Digg It 
Del.icio.us 
