discussion   |   photos   |   email   |   myProfile   |   home          Login Now | Sign Up


Forum Index

Utility ATV
  All Terrain Vehicles
  John Deere Gator
  Mule Utility Vehicles
Cars
  All Brands
  Audi VW
  BMW
  Car Tires and Maintenance
  Chrysler
  Exotic, Sports, Racing
  Ford Cars
  General Motors
  Honda
  Hyundai
  Mercedes
  News
  Nissan
  Subaru
  SUV and Trucks
  Toyota Cars
Trucks Trailers
  Chevy Pickup Trucks
  Dodge Pickup Trucks
  Ford Pickup Trucks
  Toyota Pickup Trucks
Home Building
  Alternate Electric Energy
  Barns Pole Barns
  Buying Ranch Farm Acreage
  Carpentry
  Contractors
  Electric
  Excavation
  Moldings Finish Trim
  Other Home Building
  Pellet Stoves
  Plumbing
  Wood Stoves
Tools
  Electirc Power Tools
  Gas Power Tools
  Generators
  Shop Tools
  Techniques Howto
Landscape
  Flowers Shrubs Garden
  Golf Course Maintenance
  Irrigation Systems
  Landscape Design
  Landscape Lighting
  Landscape Maintenance
  Lawn, Turf, and Grass
  Vegetable Gardening
Current Events Health Happiness
  Current Events
  Dogs and other Pets
  Electronics And Computers
  Food
  Health
  Just For Fun Off Topic
  Movies Music Games
  Personal Finance Investme
  Sports Outdoors


New As Posted | Active Subjects



Click to Post a New Message!

Discussion Boards > Active Subjects > Messages as Posted > John Deere Gator Forum

Page [ 1 ] |
Reply | Pop Up Window Reply | Add PhotoAdd Photo
 12-08-2010, 14:26 Post: 175606
ttomlinson



Join Date: Dec 2010
Location: Michigan
TractorPoint Premium Member -- 5 Tractors = Very Frequent Poster
Posts: 5

4 Filter by User
  Gator HPX

Have an 02 JD HPX. Lost power and started to Back fire about 6 mos ago. Changed coil, and plugs and was back in the race. Lost power again, however this time it is intermittent. Changed the other coil and did not correct. now have 2 new coils and set of plugs. Dealer says they have 100's of HPX in field and have not sold any coils. Unit has 200 hours on it. Any suggestions would be great. All wires are on tight as is plug wires. Runs on back cylinder with front un plugged, will not run on front with Back unplugged. Just ran with full power for 20 min, then went back to limited power. Any suggestions would be great






Reply to PostReply | Quote Post Reply to PostQuote Reply | Add PhotoAdd Photo




Bookmarks: Digg It | Del.icio.us |
 12-09-2010, 05:13 Post: 175614
gatoraider



Join Date: Nov 2008
Location: Maryland
TractorPoint Premium Member -- 5 Tractors = Very Frequent Poster
Posts: 536

3 Filter by User
  Gator HPX

I suggest an ignition module at around 350.00 I didn't think they made HPXs in 2002. If you have a buddy that has an HPX it would be nice to borrow his module and try it. It's at the right rear of the motor.






Reply to PostReply | Quote Post Reply to PostQuote Reply | Add PhotoAdd Photo




Bookmarks: Digg It | Del.icio.us |
 12-09-2010, 07:25 Post: 175616
ttomlinson



Join Date: Dec 2010
Location: Michigan
TractorPoint Premium Member -- 5 Tractors = Very Frequent Poster
Posts: 5

4 Filter by User
  Gator HPX

Would that be mounted on the passanger side frame under the box






Reply to PostReply | Quote Post Reply to PostQuote Reply | Add PhotoAdd Photo




Bookmarks: Digg It | Del.icio.us |
 12-09-2010, 07:34 Post: 175617
gatoraider



Join Date: Nov 2008
Location: Maryland
TractorPoint Premium Member -- 5 Tractors = Very Frequent Poster
Posts: 536

3 Filter by User
  Gator HPX

No sir, that's the regulator. The module is near the right rear of the motor down low. It mounts with two bolts and has a plug going to it.






Reply to PostReply | Quote Post Reply to PostQuote Reply | Add PhotoAdd Photo




Bookmarks: Digg It | Del.icio.us |
 12-09-2010, 07:44 Post: 175618
ttomlinson



Join Date: Dec 2010
Location: Michigan
TractorPoint Premium Member -- 5 Tractors = Very Frequent Poster
Posts: 5

4 Filter by User
  Gator HPX

thanks, will go out and take a look. Appreciate the help, most are stumped with the symptoms because it is not consistant.






Reply to PostReply | Quote Post Reply to PostQuote Reply | Add PhotoAdd Photo




Bookmarks: Digg It | Del.icio.us |
 12-13-2010, 17:06 Post: 175750
ttomlinson



Join Date: Dec 2010
Location: Michigan
TractorPoint Premium Member -- 5 Tractors = Very Frequent Poster
Posts: 5

4 Filter by User
  Gator HPX

Changed the ignition module, and both coils and continue to operate one cylinder. Took off both valvel covers to assure that did not have a bad lifter. All looked good. Any other suggestions would be helpful






Reply to PostReply | Quote Post Reply to PostQuote Reply | Add PhotoAdd Photo




Bookmarks: Digg It | Del.icio.us |
 12-15-2010, 06:48 Post: 175777
gatoraider



Join Date: Nov 2008
Location: Maryland
TractorPoint Premium Member -- 5 Tractors = Very Frequent Poster
Posts: 536

3 Filter by User
  Gator HPX

Have you checked the plug to see if it is firing between the electrodes when grounded to the motor? Also check compression in the cylinders, it should be around 170 and both should be near the same. If these are ok you must have a broken or loose wire in the electrical system somewhere.






Reply to PostReply | Quote Post Reply to PostQuote Reply | Add PhotoAdd Photo




Bookmarks: Digg It | Del.icio.us |
Reply | Pop Up Window Reply | Add PhotoAdd Photo


Page [ 1 ] |

Discussion Boards > Active Subjects > Messages as Posted > John Deere Gator Forum

Thread 175606 Filter by Poster:
gatoraider 3 | ttomlinson 4 |

 (advanced search)

Picture of the Day
Coachlarry

John Deere Gator - Input shaft spline or keyed
Input shaft spline or keyed


Unanswered Questions

Gas Generator Weather Protecti
Horse Injured Polyrope Electri
Do electric fences keep out de
Any Peruvian Paso Owners Out T
gas powered post driver
My new born foal is really sic
Trailer Axle
dump trailer blueprints


Active Subjects

Gas Generator Weather Protecti
Went to see Dennis Reis this w
Signs to look for prior to lab
leg injury
Broodmare has welts all over h
Some Christmas Humor For Horse
poles in the ground vs. concre
ever thought about moving?


Hot Topics

new app owner
Some Christmas Humor For Horse
Any Peruvian Paso Owners Out T
Heating a Garage
Gas Generator Weather Protecti
Do electric fences keep out de
gas powered post driver
Trailer Axle


Featured Suppliers

Mountain Creek Labradoodles
      MountainCreekLabradoodles.com





New Forums on Gun Sport Shooting and Hunting -- BarrelPoint.com New Forums on Horses ManePoint.com
Talk Horses at ManePoint
Hunting + Gun Sports at BarrelPoint



Most Viewed

+ JD Gator only runs with choke
+ Snapping noise in front and rear ends
+ Gator 620i gas in engine oil
+ What is Normal Compression
+ Gator 6x4 Overheating problem
+ John Deere Gator water in the oil
+ Is a Gator TS good for pushing snow
+ First Gator
+ snow plow wiring
+ John Deere Gator XUV aftermarket performance parts

 Most Discussion

+ Gator 620i gas in engine oil
+ JD Gator only runs with choke
+ Snapping noise in front and re
+ First Gator
+ clutch motor
+ snow plow wiring
+ Just picked up a 2000 6x4 with
+ Gator won t idle
+ e gator power
+ John Deere Gator water in the

Newest Topics

+ CX Seat Coming Apart
+ 2007 620I to 850D
+ Clutch Weights
+ Rocker arm oiling on Kawasaki fd 620d Gator 6x4
+ AMT 600 Throttle Conversion
+ Water in oil
+ 1999 Gator Transmission Leaking
+ Fuel Tank
+ 1996 gator 4X2 smoking wire and no spark
+ Gator HPX ignition module
















Turbochargers for Tractors and Industrial Machines
Cab Glass for Tractors and Industrial Machines

Alternators for Tractors and Industrial Machines
Radiators for Tractors and Industrial Machines

Driveline Components for Tractors and Industrial Machines
Starter Motors for Tractors and Industrial Machines